1 SCOPE
This standard applies to Cocoa (Cacao) Mass or Cocoa/Chocolate Liquor, and Cocoa Cake, as defined, for the use in the manufacture of cocoa and chocolate products. These products may also be sold directly to the consumer.
2 DESCRIPTIONS
2.1 Cocoa (Cacao) Mass (Cocoa/Chocolate Liquor)
Cocoa (Cacao) Mass or Cocoa/Chocolate Liquor is the product obtained from cocoa nib, which is obtained from cocoa beans of merchantable quality which have been cleaned and freed from shells as thoroughly as is technically possible with/without roasting, and with/without removal or addition of any of its constituents.
2.2 Cocoa Cake
Cocoa Cake is the product obtained by partial or complete removal of fat from cocoa nib or cocoa mass.
3 ESSENTIAL COMPOSITION AND QUALITY FACTORS
3.1 Cocoa Mass (Cocoa/Chocolate Liquor)
Cocoa Shell and Germ |
not more than 5% m/m calculated on the fat-free dry matter
|
|
or |
|
not more than 1.75% calculated on an alkali free basis (for
Cocoa Shell only) |
Cocoa Butter |
47-60% m/m |
Cocoa Shell and Germ |
not more than 5% m/m calculated on the fat-free dry matter.
|
|
or |
|
not more than 1.75% calculated on an alkali free basis (for
Cocoa Shell only) |
Cocoa Butter |
47-60% m/m |
Only those food additives listed below may be used and only within the limits specified.
4.1 Acidity regulators |
Maximum Level |
|
503(i) |
Ammonium carbonate |
Limited by GMP |
527 |
Ammonium hydroxide |
|
503(ii) |
Ammonium hydrogen carbonate |
|
170(i) |
Calcium carbonate |
|
330 |
Citric acid |
|
504(i) |
Magnesium carbonate |
|
528 |
Magnesium hydroxide |
|
530 |
Magnesium oxide |
|
501(i) |
Potassium carbonate |
|
525 |
Potassium hydroxide |
|
501(ii) |
Potassium hydrogen carbonate |
|
500(i) |
Sodium carbonate |
|
524 |
Sodium hydroxide |
|
500(ii) |
Sodium hydrogen carbonate |
|
526 |
Calcium hydroxide |
|
338 |
Orthophosphoric acid |
2.5 g/kg expressed as P205 in finished
cocoa and chocolate products |
334 |
L-Tartaric acid |
5 g/kg in finished cocoa and chocolate products |
4.2 Emulsifiers |
Maximum Level |
|
471 |
Mono- and diglycerides of edible fatty acids |
Limited by GMP |
322 |
Lecithin |
|
|
||
442 |
Ammonium salts of phosphatidic acids |
10 g/kg in finished cocoa or chocolate products |
|
||
476 |
Polyglycerol esters of interesterified ricinoleic acid |
5 g/kg in finished cocoa or chocolate products |
4.3 Flavouring Agents |
Maximum Level |
|
|
Natural and artificial flavours, except those which reproduce the flavour
of chocolate or milk |
Limited by GMP |
|
Vanillin |
|
|
Ethyl vanillin |
5.1 Heavy Metal |
Maximum Level |
Lead |
1 mg/kg |
6.1 It is recommended that the products covered by the provisions of this standard be prepared and handled in accordance with the appropriate sections of the Recommended International Code of Practice - General Principles of Food Hygiene (CAC/RCP 1-1969, Rev. 3-1997), and other relevant Codex of Hygenic Practice and Codes of Practice.
The products should comply with any microbiological criteria established in accordance with the Principles for the Establishement and Application of Microbiological Criteria for Foods (CAC/GL 21-1997).
6.2 To the extent possible in good manufacturing practice, the products shall be free from objectionable matter.
6.3 When tested by the appropriate methods of sampling and examination, the products:
(a) shall be free from microorganisms capable of development under normal conditions of storage; and7 LABELLING(b) shall not contain any substances originating from microorganisms in amounts which may represent a hazard to health.
In addition to the Codex General Standard for Labelling of Prepackaged Foods - CODEX STAN 1-1985, Rev.1-1991 - the following apply:
7.1 Name of the Product
7.1.1 The name used to describe the product defined under Section 2.1 and complying with provisions of Section 3.1 of the Standard include Cocoa (Cacao) Mass, Cocoa/Chocolate Liquor, Cocoa Paste, Unsweetened Chocolate and Bitter Chocolate.
In the case of products traded internationally, the name of the product shall be acceptable to the importing authorities.
7.1.2 The name of the product described under Section 2.2 and complying with provisions of Section 3.2 of the Standard shall be: Cocoa Cake.
7.2 Labelling of Non-Retail Containers
Information required in Section 7.1 of this Standard and Section 4 of the Codex General Standard for the Labelling of Prepackaged Foods shall be given either on the container or in accompanying documents, except that the name of the product, lot identification, and the name and address of the manufacturer or packer shall appear on the container. However, lot identification, and the name and address of the manufacturer or packer may be replaced by an identification mark provided that such a mark is clearly identifiable with the accompanying documents.
8 METHODS OF ANALYSIS AND SAMPLING
8.1 Determination of Cocoa Shell
According to AOAC 968.10 and 970.23.
8.2 Determination of Fat Content
According to AOAC 963.15 or IOCCC 14 (1972).
8.3 Determination of Lead
According to AOAC 986.15 (Codex general method).